• 1 – 20 t/h
  • 0.7 – 2 Mpa
  • Industrial
  • In Stock
  • Nature gas, coke oven gas, biogas, methanol, liquid propane gas, diesel, heavy oil, light oil, crude oil, etc.
  • Heat supplying, chemical, food, textile, printing and dyeing, cigarettes and tobacco, fodder, pharmacy, building materials, brewery, rubber, hospital etc.

WSN series gas / oil fired industrial horizontal steam boiler is a kind of safety and high efficiency heating equipment with fully automatic intelligent control system. It’s a boiler shell type 3 passes wetback oil/gas fired boiler. Usually, the WNS series steam boilers widely used for industry production and processing, such as textile mill, medicine industry, food & beverage industry, chemical industry, garment industry, food processing industry, and wood processing industry, moreover, it could be used for central heating in enterprise, hotel, hospital, civil architecture, etc.

Waste Heat Recovery System Using Coal-Fired Boile

Meanwhile, the boiler burns large amount of fuel to heat the heating network return water to the supply temperature. A specially designed waste heat recovery system, which can reduce exhaust flue gas temperature to 60–70 °C and recycle large amount of sensible heat and latent heat in the flue gas to heat the return water, is designed.

Waste heat recovery and utilization system of boile

Waste heat recovery and utilization system of boiler flue gas. Because there are some design and installation defects in the early design and installation of the boiler, in the long-term operation of the later boiler, the ash accumulation, wear and tear in the boiler and the deviation of coal quality from the design value are the main factors affecting the boiler.

Experimental Study on Operation Regulation of

2019-2-21 · flue gas waste heat recovery system (CWHRS) has been used in a 1000 MW double–reheat coal–fired unit [17]. A steam–air FAH on bypass waste heat use system was proposed to heat the inlet air of a utility boiler [18]. Yan et al. [19] suggested use the flue gas waste heat after wet FGD to preheat air based on a bypass waste heat use system.

Exhaust Boiler, Exhaust Boiler Suppliers an

Alibaba.com offers 4,508 exhaust boiler products. About 4% of these are boilers, 3% are gas water heaters, and 1% are boiler parts. A wide variety of exhaust boiler options are available to you, such as natural circulation, once through, and cookware sets.

An Improved System for Utilizing Low-Temperatur

2017-10-20 · have adopted the waste heat utilization system (WHUS) to heat up the condensed water. The employed low-temperature economizer promotes the boiler efficiency by 2 percentage points and the net plant efficiency by 0.8 to 0.9 percentage point [31–33]. There are two major issues to be addressed for low-grade heat recovery from flue gas: (1

(Coal fired steam boiler).d

2017-8-18 · 80% between. Coal fired steam boiler composed of coal-fired steam boiler consists of pulverized coal preparation system, the heat absorption. Coal-fired steam of

boiler system heating without exhaust | Thermal oi

boiler system heating without exhaust in Sugar Mill. Steam is very important for the sugar mill. Steam boiler is used for heating, gelatinization, and saccharify, etc. Heating equipment is equipped under mash kettle, and then steam produced by boiler system heating without exhaust enter into the heating equipment, and then heat the raw materials for starch hydrolysis.

Boiler Systems | ERK Energy Syste

ERK's boilers cover a very wide spectrum of heat recovery systems, ranging from units using clean exhaust gases, such as from gas turbines and engines to complicated exhaust gases, such as from steel or cement plants. These clients include small industrial as well as utility HRSGs (heat recovery

Recovery boiler - Wikiped

2019-9-8 · Recovery boiler is the part of Kraft process of pulping where chemicals for white liquor are recovered and reformed from black liquor, which contains lignin from previously processed wood. The black liquor is burned, generating heat, which is usually used in the process or in making electricity, much as in a conventional steam power plant.The invention of the recovery boiler by G.H. Tomlinson


The convective elements of boilers fired by municipal industrial or other waste materials are often referred to as heat recovery boilers although, apart from their geometry, they are more akin to the rear end of a furnace-fired boiler. Perhaps the most common heat recovery boiler is now the gas turbine heat recovery boiler.

Use Feedwater Economizers for Waste Heat Recove

2017-6-3 · Use Feedwater Economizers for Waste Heat Recovery A feedwater economizer reduces steam boiler fuel requirements by transferring heat from the flue gas to incoming feedwater. Boiler flue gases are often rejected to the stack at temperatures more than 100°F to 150°F higher than the temperature of the generated steam. Generally, boiler

ModelRated steam capacity(t/h)Rated working pressure(Mpa)Rated steam temperature(℃)Maximum transport size(m)
WNS1.5-1.0-Y(Q) 1.511843.0×1.8×2.0
WNS2-1.0-Y(Q) 211844.4×2.1×2.5